Ilaria Rubino is shown in this undated handout image at University of Alberta. Alberta researcher Rubino has developed technology allowing mostly salt to kill pathogens in COVID-19 droplets as they land on a mask. THE CANADIAN PRESS/HO-University of Alberta

Ilaria Rubino is shown in this undated handout image at University of Alberta. Alberta researcher Rubino has developed technology allowing mostly salt to kill pathogens in COVID-19 droplets as they land on a mask. THE CANADIAN PRESS/HO-University of Alberta

Alberta researcher gets award for COVID-19 mask innovation

The salt-coated mask is expected to be available commercially next year after regulatory approval.

Salt that crystallizes with sharp edges is the killer ingredient in the development of a reusable mask because any COVID-19 droplets that land on it would be quickly destroyed, says a researcher who is being recognized for her innovation.

Ilaria Rubino, a recent PhD graduate from the department of chemical and materials engineering at the University of Alberta, said a mostly salt and water solution that coats the first or middle layer of the mask would dissolve droplets before they can penetrate the face covering.

As the liquid from the droplets evaporates, the salt crystals grow back as spiky weapons, damaging the bacteria or virus within five minutes, Rubino said.

“We know that after the pathogens are collected in the mask, they can survive. Our goal was to develop a technology that is able to inactivate the pathogens upon contact so that we can make the mask as effective as possible.”

Rubino, who collaborated with a researcher at Georgia State University in Atlanta to advance the project she started five years ago, was recognized Tuesday with an innovation award from Mitacs. The Canadian not-for-profit organization receives funding from the federal government, most provinces and Yukon to honour researchers from academic institutions.

The reusable, non-washable mask is made of a type of polypropylene, a plastic used in surgical masks, and could be safely worn and handled multiple times without being decontaminated, Rubino said.

The idea is to replace surgical masks often worn by health-care workers who must dispose of them in a few hours, she said, adding the technology could potentially be used for N-95 respirators.

The salt-coated mask is expected to be available commercially next year after regulatory approval. It could also be used to stop the spread of other infectious illnesses, such as influenza, Rubino said.

Dr. Catherine Clase, an epidemiologist and associate professor of medicine at McMaster University in Hamilton, said the “exciting” technology would have multiple benefits.

Clase, who is a member of the Centre of Excellence in Protective Equipment and Materials in the engineering department at McMaster, said there wasn’t much research in personal protective equipment when Rubino began her work.

“It’s going to decrease the footprint for making and distributing and then disposing of every mask,” she said, adding that the mask could also address any supply issues.

The Public Health Agency of Canada recently recommended homemade masks consist of at least three layers, with a middle, removable layer constructed from a non-woven, washable polypropylene fabric to improve filtration.

Conor Ruzycki, an aerosol scientist in the University of Alberta’s mechanical engineering department, said Rubino’s innovation adds to more recent research on masks as COVID-19 cases rise and shortages of face coverings in the health-care system could again become a problem.

Ruzycki, who works in a lab to evaluate infiltration efficiencies of different materials for masks and respirators, is also a member of a physician-led Alberta group Masks4Canada, which is calling for stricter pandemic measures, including a provincewide policy on mandatory masks.

Camille Bains, The Canadian Press


Like us on Facebook and follow us on Twitter.

Want to support local journalism during the pandemic? Make a donation here.

Coronavirus

Get local stories you won't find anywhere else right to your inbox.
Sign up here

Just Posted

A health-care worker prepares a dose of the Pfizer-BioNTech COVID-19 vaccine at a COVID-19 vaccine clinic in Toronto on Thursday, January 7, 2021. THE CANADIAN PRESS/Nathan Denette
65 new cases of COVID-19 in Interior Health

Overall, B.C. is seeing a decrease in COVID-19 cases

FILE - In this April 19, 2021, file photo, Keidy Ventura, 17, receives her first dose of the Pfizer COVID-19 vaccine in West New York, N.J. States across the country are dramatically scaling back their COVID-19 vaccine orders as interest in the shots wanes, putting the goal of herd immunity further out of reach. (AP Photo/Seth Wenig, File)
5 more deaths, 131 new cases of COVID-19 in Interior Health over the weekend

Those 18-years and older in high-transmission neighbourhoods can register for the vaccine

District of Clearwater meetings are open to the public. The meeting agendas and past meetings minutes can be viewed on the DOC's website. Every meeting has time allocated at the end for comments from the public.
District of Clearwater hires new chief adminstrative officer

The new CAO will arrive at the end of June.

A medical worker prepares vials of the COVID-19 vaccines, Chinese Sinopharm, left, Sputnik V, center, and Pfizer at a vaccine centre, in the Usce shopping mall in Belgrade, Serbia, Thursday, May 6, 2021. Serbian authorities are looking for incentives for people to boost vaccination that has slowed down in recent weeks amid widespread anti-vaccination and conspiracy theories in the Balkan nation. The government has also promised a payment of around 25 euros to everyone who gets vaccinated by the end of May. (AP Photo/Darko Vojinovic)
38 new COVID-19 cases, more than 335k vaccines administered in Interior Health

Interior Health also to start targeted vaccinations in high transmission neighbourhoods

FILE PHOTO
Second doses of COVID-19 vaccine will be available, as AstraZeneca supply runs low: Interior Health

Province expecting large volumes of Pfizer BioNTech as age-based cohort immunization program ramps up

B.C. Labour Minister Harry Bains in the B.C. legislature, May 13, 2019. (Hansard TV)
VIDEO: B.C. to provide 3 days of sick pay for COVID-19 absences

Province will support employers on cost, labour minister says

RCMP. (Black Press File)
Major Crimes called in after two bodies discovered on remote road near Penticton

A manhunt involving a police helicopter took place on May 10

Vancouver court on Tuesday, March 23, 2021. THE CANADIAN PRESS/Darryl Dyck
Defence lawyers call foul as Crown counsel granted access to COVID-19 vaccines

Defence attorneys are pushing the province to extend inoculation access to workers in courtrooms across B.C.

The RCMP logo is seen outside Royal Canadian Mounted Police “E” Division Headquarters, in Surrey, B.C., on Friday April 13, 2018. Indigenous leaders are calling for an investigation into the conduct of Mounties on Vancouver Island after two police shootings of members of a small First Nations community in three months. THE CANADIAN PRESS/Darryl Dyck
Indigenous leaders call for clarity, investigation into RCMP after B.C. shooting

The RCMP declined to comment on the requests by Indigenous leaders

Colleen Price, Vancouver Island University’s bachelor of science in nursing program chairperson, says she is impressed with how students have persevered through the COVID-19 pandemic. (Chris Bush/News Bulletin)
Next generation of B.C. nurses already showing resilience

University program head says learning had to be adjusted amidst pandemic

Two-year-old Kashius Weme rides at the Steve Smith Memorial Bike Park in Nanaimo on Tuesday, May 11. The youngster’s precocious bike-riding ability is already attracting cycle sponsors. (Chris Bush/News Bulletin)
2-year-old B.C. bike rider already attracting cycle sponsors

Nanaimo’s Kashius Weme has a knack for extreme cycle sports

Keith MacIntyre - BC Libertarian
Penticton’s Keith MacIntyre new leader of the B.C. Libertarian Party

The Penticton businessman was voted in by members of the party on May 8

RCMP are searching for Philip Toner, who is a 'person of interest' in the investigation of a suspicious death in Kootenay National Park last week. Photo courtesy BC RCMP.
Man sought in suspicious Kootenay death found in Lake Country

Philip Toner is a person of interest in the death of Brenda Ware

Vernon North Okanagan RCMP reported to 287 mental health calls between Jan. 1, 2021, and May 1. (Black Press files)
‘It’s not the police’s responsibility to deal with mental health calls’: Vernon RCMP

RCMP remind public to take care of mental health and well-being, while better solutions are sought

Most Read